Comments on: How much will it cost to replace the crankshaft on my Snapper Lawnmower? http://www.qualitylawnmower.com/blog/how-much-will-it-cost-to-replace-the-crankshaft-on-my-snapper-lawnmower/ Thu, 17 May 2012 15:13:49 +0000 http://wordpress.org/?v=2.7 hourly 1 By: leo http://www.qualitylawnmower.com/blog/how-much-will-it-cost-to-replace-the-crankshaft-on-my-snapper-lawnmower/comment-page-1/#comment-1020 leo Mon, 09 Mar 2009 18:22:10 +0000 http://www.qualitylawnmower.com/blog/how-much-will-it-cost-to-replace-the-crankshaft-on-my-snapper-lawnmower/#comment-1020 Dismantle the whole blade assembly. Then start the engine,if running OK,then engine no problem. Next check which part of the blade assembly is distorted. This distortion will cause off balance during running Is is extremely difficult to damage the crankshaft under normal usage cos the crankshaft is the most robust of the engine component Dismantle the whole blade assembly.
Then start the engine,if running OK,then engine no problem.
Next check which part of the blade assembly is distorted.
This distortion will cause off balance during running
Is is extremely difficult to damage the crankshaft under normal usage cos the crankshaft is the most robust of the engine component

]]> By: bvbvjk http://www.qualitylawnmower.com/blog/how-much-will-it-cost-to-replace-the-crankshaft-on-my-snapper-lawnmower/comment-page-1/#comment-1019 bvbvjk Mon, 09 Mar 2009 04:57:22 +0000 http://www.qualitylawnmower.com/blog/how-much-will-it-cost-to-replace-the-crankshaft-on-my-snapper-lawnmower/#comment-1019 You need to check the blade first..Make sure it isn't bent you need to check it's balance eying it wont work... It does happen but it's rare to bend the shaft before the blade..If it's determined to be the crank buy a used mower or spring for a new one. You need to check the blade first..Make sure it isn’t bent you need to check it’s balance eying it wont work… It does happen but it’s rare to bend the shaft before the blade..If it’s determined to be the crank buy a used mower or spring for a new one.

]]> By: Todd B http://www.qualitylawnmower.com/blog/how-much-will-it-cost-to-replace-the-crankshaft-on-my-snapper-lawnmower/comment-page-1/#comment-1018 Todd B Sun, 08 Mar 2009 08:51:07 +0000 http://www.qualitylawnmower.com/blog/how-much-will-it-cost-to-replace-the-crankshaft-on-my-snapper-lawnmower/#comment-1018 I hate to say this, if the shaft is bent then the engine is damaged even if you can start it. The crank is one of the most critical parts in the engine, it is what transfers the energy from the piston to the machine. Most cranks start off around $150, then you have the labor of taking the engine completely apart, and then back together. That takes at least 2 hours. So you need to justify the cost of repair to a new one. Snapper is a great machine, but the choice is yours. I hate to say this, if the shaft is bent then the engine is damaged even if you can start it. The crank is one of the most critical parts in the engine, it is what transfers the energy from the piston to the machine. Most cranks start off around $150, then you have the labor of taking the engine completely apart, and then back together. That takes at least 2 hours. So you need to justify the cost of repair to a new one. Snapper is a great machine, but the choice is yours.

]]> By: zzebra http://www.qualitylawnmower.com/blog/how-much-will-it-cost-to-replace-the-crankshaft-on-my-snapper-lawnmower/comment-page-1/#comment-1017 zzebra Sat, 07 Mar 2009 11:38:36 +0000 http://www.qualitylawnmower.com/blog/how-much-will-it-cost-to-replace-the-crankshaft-on-my-snapper-lawnmower/#comment-1017 CHECK THE BLADE FIRST AND IF IT IS THE SHAFT FIND A NEW MOTOR ON EBAY MUCH CHEAPER CHECK THE BLADE FIRST AND IF IT IS THE SHAFT FIND A NEW MOTOR ON EBAY MUCH CHEAPER

]]> By: renpen http://www.qualitylawnmower.com/blog/how-much-will-it-cost-to-replace-the-crankshaft-on-my-snapper-lawnmower/comment-page-1/#comment-1016 renpen Wed, 04 Mar 2009 07:40:37 +0000 http://www.qualitylawnmower.com/blog/how-much-will-it-cost-to-replace-the-crankshaft-on-my-snapper-lawnmower/#comment-1016 Check the blade adaptor on the end of the crankshaft. The key could be sheared. If the crank is bent the motor is toast. The shaft can be straightened in some cases but for the most part it is not going to happen. Check the blade adaptor on the end of the crankshaft. The key could be sheared. If the crank is bent the motor is toast. The shaft can be straightened in some cases but for the most part it is not going to happen.

]]> By: coondaddy http://www.qualitylawnmower.com/blog/how-much-will-it-cost-to-replace-the-crankshaft-on-my-snapper-lawnmower/comment-page-1/#comment-1015 coondaddy Mon, 02 Mar 2009 19:46:51 +0000 http://www.qualitylawnmower.com/blog/how-much-will-it-cost-to-replace-the-crankshaft-on-my-snapper-lawnmower/#comment-1015 Well I hate to say this but you probably did damage the engine. to tell for sure tie back the bail to the top of the handle (the piece you pull back to run and release to shut off the mower) and disconnect the spark plug wire. Then flip the mower on its side, carburetor up to prevent flooding and spin the blade by hand. if it wobles from the shaft it is not worth repair, if it only wobbles at the blade you may have only bent the blade and/or the blade hub, although most of the time the damage is to the crankshaft. Most of the mowers that come in to the shop shaking like that are diagnosed on the spot as not worth repair just by looking at the shaft. With a 4-6 hp motor it is not worth parts or labor to replace a crankshaft and it would be better to buy a new mower or a new motor and mount it on the old deck yourself. Your talking $60 an hour shop labor fee plus the crankshaft, oil seals, crankcase gaskets, probably well over $100 and you could easily spend over an hour fixing it so thats almost 200 while a brand new motor might cost you $350 Well I hate to say this but you probably did damage the engine. to tell for sure tie back the bail to the top of the handle (the piece you pull back to run and release to shut off the mower) and disconnect the spark plug wire. Then flip the mower on its side, carburetor up to prevent flooding and spin the blade by hand. if it wobles from the shaft it is not worth repair, if it only wobbles at the blade you may have only bent the blade and/or the blade hub, although most of the time the damage is to the crankshaft. Most of the mowers that come in to the shop shaking like that are diagnosed on the spot as not worth repair just by looking at the shaft. With a 4-6 hp motor it is not worth parts or labor to replace a crankshaft and it would be better to buy a new mower or a new motor and mount it on the old deck yourself. Your talking $60 an hour shop labor fee plus the crankshaft, oil seals, crankcase gaskets, probably well over $100 and you could easily spend over an hour fixing it so thats almost 200 while a brand new motor might cost you $350

]]> By: kid360roadrash http://www.qualitylawnmower.com/blog/how-much-will-it-cost-to-replace-the-crankshaft-on-my-snapper-lawnmower/comment-page-1/#comment-1014 kid360roadrash Sun, 01 Mar 2009 22:09:55 +0000 http://www.qualitylawnmower.com/blog/how-much-will-it-cost-to-replace-the-crankshaft-on-my-snapper-lawnmower/#comment-1014 I hate to say this, but by the time you get a new crankshaft, find out if anythings been damaged inside the motor, its just cheeper replacing the motor or entire thing. You can find cheep push mowers for sale/free - people always are putting them out. Kidd I hate to say this, but by the time you get a new crankshaft, find out if anythings been damaged inside the motor, its just cheeper replacing the motor or entire thing. You can find cheep push mowers for sale/free - people always are putting them out.
Kidd

]]>